攪拌車屬于工程車，基建工程需求量大，自然攪拌車的需求量也跟著增大。以往小型混凝土攪拌車司機多多少少都會(huì )出現一些超載的情況，以此來賺更多的錢。但現在隨著、路政等部門監管力度加大，如今的攪拌車想要超載太難了！那么小型混凝土攪拌車拉多少才算不超載呢？這是有規定的：

Mixers are engineering vehicles, and the demand for infrastructure projects is large, so the demand for natural mixers is also increasing. In the past, drivers of small concrete mixers were more or less overloaded to earn more money. But now, with the increased supervision of environmental protection, road administration and other departments, it is too difficult to overload the mixer truck today! So how much can a small concrete mixer be pulled without overloading? This is regulated:

車輛載質量核定是交通管理機關對車輛在干硬路面上行駛，所允許的量大載質量的審核和規定。對于定型或進口的機動車，載質量按原車使用說明書核定；對于經過改裝的機動車，載質量參照發動機功率、底盤強度、輪胎承載能力及原車載質量，以小值核定；對于掛車的載質量，參照改裝車的方法核定。

The verification of vehicle load quality refers to the verification and regulation of the traffic management authority on the quantity and large load quality allowed for vehicles running on dry and hard roads. For national finalized or imported motor vehicles, the load capacity shall be checked according to the original vehicle operating instructions; For the refitted motor vehicle, the load capacity shall be checked and determined at a small value with reference to the engine power, chassis strength, tire bearing capacity and original vehicle weight; The loading mass of the trailer shall be checked by reference to the method of refitting the vehicle.

另外，一般車輛合格證上都標示有額定載質量，只要攪拌車拉的混凝土質量不超過這個額定載質量的噸位，便是正常行駛；若超過額定載質量的數值，便為超載行駛，被交警查到，可能視超載情況輕重，會(huì )有不同處罰！

In addition, the general vehicle certificate is marked with the rated load mass. As long as the concrete mass pulled by the mixer truck does not exceed the tonnage of the rated load mass, it is normal driving; If the value exceeds the rated load mass, it means that the vehicle is overloaded. If the traffic police find it, they may impose different penalties depending on the severity of the overload!

此外您在使用攪拌車工作時要注意事項，如：

In addition, you should pay attention to safety precautions when using the mixer, such as:

在運輸途中，混凝土攪拌罐車應保持3-6轉、分的慢速運轉。在正常攪拌行駛時，高時速不得超過50km/h。在轉彎時不要太急，同時轉彎速度不大于15km/h，否則會(huì )有翻車危險?？哲?chē)時速不得超過60km/h。當塌落度損失過大時，可在符合混凝土設計配合比例要求的條件下適量加水，此項工作須由試驗室技術人員完成。除此之外，嚴禁往攪拌罐內加水。

During transportation, the concrete mixing tank truck shall operate at a slow speed of 3-6 rpm. During normal mixing driving, the high speed shall not exceed 50km/h. Don't turn too fast, and the turning speed is not more than 15km/h, otherwise there will be a danger of rollover. The empty speed shall not exceed 60km/h. When the slump loss is too large, the appropriate amount of water can be added under the condition of meeting the requirements of the design mix proportion of concrete. This work must be completed by the laboratory technicians. In addition, it is strictly prohibited to add water to the mixing tank.

駕駛員應對混凝土攪拌罐車經常進行保養，以保證攪拌罐車的使用壽命，以及正常工作。每周應該給托輪油咀加注一次高壓油脂，每班給托輪軌道加一點含石墨或硫化鉬潤滑脂。每周潤滑一次油泵傳動軸。更多相關注意事項，您可以隨時來我們網站http://www.zgclmw.com進行咨詢了解！

The driver shall maintain the concrete mixing tank truck frequently to ensure its service life and normal operation. The supporting wheel oil nozzle shall be filled with high-pressure grease once a week, and the supporting wheel track shall be filled with a little graphite or molybdenum sulfide grease every shift. Lubricate the oil pump drive shaft once a week. For more precautions, you can visit our website at any time http://www.zgclmw.com Ask about it!