混凝土攪拌車對預拌混凝土的輸送時間要求是怎樣的呢？下面小編為您講解一番。
What is the delivery time requirement of concrete mixer for ready mixed concrete? The following editor will explain it to you.
任何預拌混凝土在未添加緩凝劑的情況下，都在1小時左右進入初凝狀態，這時再進行混凝土澆注施工將影響混凝土的工程質量。因此攪拌車運送預拌混凝土有其時間控制的輸送半徑要求。一般控制在1小時以?xún)取?/div>
Any ready mixed concrete will enter the initial setting state in about 1 hour without adding retarder. At this time, the concrete pouring will affect the quality of the concrete. Therefore, the transportation of ready mixed concrete by mixer truck has its time controlled transportation radius requirements. Generally controlled within 1 hour.
從商用預拌混凝土進料到卸料完畢的長時間為90分鐘，且攪拌筒總轉數不大于300轉。如嫌原有的卸料槽不夠長，需另外接長時，請用支柱將接長部分撐住。
The long time from the feeding of commercial ready mixed concrete to the completion of unloading is 90 minutes, and the total number of revolutions of the mixing drum is not more than 300. If the original discharge chute is not long enough and needs to be lengthened, please support the lengthened part with a pillar.
混凝土出料完畢后，應迅速對攪拌筒內部進行沖洗。注意：如不及時沖洗，不僅會(huì )造成攪拌筒內混凝土的粘結，使裝載量減少，進料不暢，還會(huì )給機構帶來故障，是事故的誘發因素之一。務必注意!
After the concrete is discharged, the inside of the mixing drum shall be washed quickly. Note: if not washed in time, it will not only cause the concrete in the mixing drum to bond, reduce the loading capacity, and obstruct the feeding, but also bring failure to the mechanism, which is one of the inducing factors of the accident. Be careful!
空車行駛時，攪拌筒應以與裝載有料時行駛同樣的攪動的轉速回轉。
When the truck is running empty, the mixing drum shall rotate at the same stirring speed as when the truck is loaded.
滿載的混凝土正在是正轉的時候若是需要反轉，那么就需要操控手柄使其能夠正傳挺穩之后，在操控手柄讓其反轉。不可再進行正轉的時候操控手柄讓其反轉。
If the full load concrete needs to be reversed when it is rotating forward, it needs to control the handle to make it forward and stable, and then reverse it. When the forward rotation is no longer possible, control the handle to reverse it.
混凝土攪拌車的工作裝置的連續時間不能夠有超過了八小時。
The continuous time of the working device of the concrete mixer shall not exceed eight hours.
車輛處于空載的駕駛過程中，攪拌筒不能夠停轉，以免在行駛的過程中在顛簸的時候所造成了拖輪以及滾道的磕碰使其出現了異常的損壞。
When the vehicle is in the no-load driving process, the mixing drum cannot stop running, so as to avoid the collision of the tug and the raceway caused by the bumping during the driving process and the abnormal damage.
混凝土攪拌車在進行輸送著混凝土的容量、質量、以及其塌落度都須是要符合著其混凝土行業的要求以及標準的。
The capacity, quality and slump of concrete transported by the concrete mixer must meet the requirements and standards of the concrete industry.
注意：攪拌車行駛時，如攪拌停止回轉，則攪拌筒滾道與攪拌筒托輪上會(huì )產生壓痕，并會(huì )發生異常噪聲。因此，務請注意。更多相關事項就來我們網站http://www.zgclmw.com咨詢吧。
Note: when the mixer truck is running, if the mixing stops rotating, there will be indentation on the mixing drum raceway and the mixing drum supporting wheel, and abnormal noise will occur. Therefore, please be careful. For more information, please visit our website http://www.zgclmw.com Consult.
